The Fermentation and Distillation of Alcohol By Bhanupriya Chettiar 301 Group Members: Bhanupriya Chettiar‚ Rachel Min‚ Zoe Chandler‚ Bianca Main Aim The aim of the practical is to prepare ethanol by fermentation and to isolate it by fractional distillation. Introduction This practical’s aim is to prepare ethanol using two steps; fermentation and then fractional distillation. Many alcoholic drinks for example‚ brandy and whisky‚ are prepared using this method but to a larger scale. The first
Premium Water Oxygen Ethanol
Experiment D: Separation of Alcohols by Fractional Distillation Pre-lab Properties: Propanol‚ butanol‚ methanol Purpose: To separate two alcohols by distillation and analyze results with GC. Do not plug mantle directly into electrical outlet‚ use controller! Use 40/60 mol percent propanol/butanol (no cyclohexane or toluene are used in this lab because they are more toxic) Set up fractional distillation Set heat at highest level to start‚ then turn back down to 60-80% when vapor starts up column
Premium Distillation Ethanol
GOAL The goal of this experiment was to separate Toluene and Hexane by distillation and gas chromatography based on their difference in boiling points. The boiling point of hexane is 69 degrees Celsius and the boiling point of toluene is 110 degrees Celsius. Three fractions were collected for both simple and fractional distillation. The first fraction was hexane since it had the lower boiling point. The second fraction was a mixture of toluene and hexane. The third fraction was toluene since it had
Premium Distillation Gas Water
phosphoric acid‚ and one boiling chip‚ were all added to a 10 mL round bottom flask that would be attached to the end of an assembled simple distillation set up. A sand bath was placed atop a hot plate‚ and the simple distillation mechanism was lowered into the sand bath with the bottom most piece (the 10 mL round bottom flask) submerged about half way. The distillation process was completed after a sufficient amount of liquid distillate had accumulated within the Hickman Still Head. Smaller volumes were
Premium Chemistry Water Hydrochloric acid
students to familiarize and perfect the simple distillation method to produce 4-Methylcyclohexene and to gain experience using an IR spectroscopy to characterize the product of the reaction in favor of equilibrium. B. Results and Discussion: C. Experimental: 24 mL of 4-methylcyclohexanol‚ 5mL of phosphoric acid‚ and 1mL of concentrated sulfuric acid was added to a 250 mL round bottom flask and mixed thoroughly with a magnetic stirrer. A simple distillation set up was installed with a 250mL round
Free Distillation Sulfuric acid Infrared spectroscopy
SIMPLE DISTILLATION OF VODKA (ANTONOV) Kristel Joy M. Tan‚ Joshua Michael L. Torres‚ Pauleen Anne S. Vanadero‚ Paulene Arielle P. Ynzon and Rachel Pauline E. Zaballero Group 10‚ 2D Medical Technology‚ Faculty of Pharmacy‚ University of Santo Tomas ABSTRACT Distillation is the most common technique‚ it is a process wherein the liquid is separated from the solution by boiling the liquid solution and condensing the vapor in order to get the distillate. There are four kind of distillation: simple distillation
Premium Distillation
Theory: Distillation is the conversion of a mixture of substance into vapors which is afterwards condensed to the liquid form. It cans separation or purification of substances by taking advantage of differences in volatility. The purpose of this lab is comparing the efficiency of two distillation methods with the mixture of ethanol and 1-butanol. in theory the fractional distillation should be more efficient because of the steel sponge. The sponge acted as surface area for gas to condense on. This
Premium Distillation Boiling point
Organic Chemistry I Simple and Fractional Distillation The Simple and Fractional distillation experiment was divided into two parts. We split up the procedure in this experiment. My group did the simple distillation and we received the Fractional distillation from another group in class. In this experiment‚ we examined the effectiveness of fractional and simple distillation to determine which is more successful at extracting a pure sample. This experiment was very successful. We are able to
Premium Distillation
EXPERIMENT 2: BATCH DISTILLATION AT CONSTANT REFLUX OBJECTIVE: To operate a batch distillation unit at constant reflux. To examine the change in top and bottom composition over time in a batch distillation. PROCEDURES: 1. Perform the general start-up procedures (Section 4). Refer appendix 1. 2. Record initial volume and refractive index of the liquid mixture in the reboiler. 3. Set the heater power to 1.5kW. 4. Set reflux timer to 10 second for set 1 and 30 second for set 2. ( Note: Set 1:
Premium Distillation Chemical engineering Thermodynamics
Fractional Distillation & Gas Chromatography Exp. 1 Pre-Lab: 1) When two substances whose molecules are very similar from a liquid solution‚ the vapor pressure of the mixture related to vapor pressure of the pure substance. Also it could be defined as a two liquid are ideal solution when they don’t react with each other and they make no association. 2) Are a mixture of at least two different liquid‚ and known also as a mixture of two or more liquid in such away that its component
Premium Distillation Chemical compound