Preview

Hardness Tests And Charpy Impact Test

Better Essays
Open Document
Open Document
2289 Words
Grammar
Grammar
Plagiarism
Plagiarism
Writing
Writing
Score
Score
Hardness Tests And Charpy Impact Test
TITLE
Hardness Tests And Charpy Impact Test
OBJECTIVE
1. To compare the hardness of the carbon steel, mild steel and ASSAB steel using three different hardness tests, which are Vickers Hardness Test, Rockwell Hardness Test and Brinell Hardness Test. 2. To study the hardness of mild steel, carbon steel and ASSAB which is an important in engineering to design structures or components that related in mechanical properties

3. To determine the resistance of carbon steel and mild steel against sudden impact by Charpy Impact Test.

INTRODUCTION

Hardness is a measure of a material’s resistance to localized plastic deformation. It also is one of the important properties to be considered. Mechanical properties of metals are a vital of engineering to design the components which using predetermined materials such that unacceptable levels of deformation and failure will not occur.

Hardness is a resistance of properties of material to permanent (plastic) deformation caused by steel ball or pyramid-shape diamond when it is pressed onto its surface. There will be three basic method of Hardness Test that will be carried out on carbon and metal: (a) Vickers Test (b) Rockwell Test (c) Brinell Test

THEORY

1. Vickers Test
VHN = Applied load / Surface area of depression
=
= 1.854 P/ d2 (approximate)
Where P = applied load (kgf) d = (d1+ d2) / 2 (mm)

2. Rockwell Test HRC = 100 – d /0.002 HRB = 130 – d /0.002
Where d = depth of the indentation

3. Brinell Test
BHN = Applied force / curve area of indentation P / D/2 [D - (D² - d²)] = P / Dh Where P = applied load (kgf) D = diameter of steel ball (mm) d = diameter of resulting indentation (mm) h = depth of indentation (mm) = ½ [D - (D² - d²)]

APPARATUS 1. Set of Vickers

You May Also Find These Documents Helpful

  • Powerful Essays

    Nt1310 Unit 3 Lab Report

    • 1306 Words
    • 6 Pages

    The force applied and the diameter of the diameter of a hardened steel ball is kept constant while four different specimen blocks namely, aluminum, brass, copper and mild steel are penetrated by the indentation steel ball to create different indentations on each of them. The diameters of the indentions allow us to obtain the Brinell Hardness number to predict the hardest and the softest material among them. The experimental data would also allow us to compare the hardness measured with the other published results from other…

    • 1306 Words
    • 6 Pages
    Powerful Essays
  • Good Essays

    Aluminum Foil Lab

    • 447 Words
    • 3 Pages

    The purpose of this lab is to determine which brands of heavy duty and regular aluminum are the best to buy based on their price and their thickness.…

    • 447 Words
    • 3 Pages
    Good Essays
  • Satisfactory Essays

    master

    • 530 Words
    • 3 Pages

    Hardness is the ability of a material to resist scratching, wear and tear and indentation.…

    • 530 Words
    • 3 Pages
    Satisfactory Essays
  • Powerful Essays

    cold rolling brass

    • 1415 Words
    • 6 Pages

    hardness and strength that result from the working operation can be important, it is often…

    • 1415 Words
    • 6 Pages
    Powerful Essays
  • Powerful Essays

    The foundation of Materials Science lies in characterization of a material’s properties. Among those properties the greatest interest lies in the strength of materials, being the most basic requirement for any kind of construction. This lab aims first to describe the strength of 1045 annealed and cold-rolled steel, 2024-T4 aluminum, and cast iron through tensile testing. This includes characterization of yield strengths, modulus of elasticity, ultimate tensile strength, and fracture strength for each material. An emphasis is placed on elastic-plastic deformation in terms of ductility and how temperature and fatigue can affect this transition. Elastic and plastic…

    • 3265 Words
    • 14 Pages
    Powerful Essays
  • Good Essays

    Alloys Research Task

    • 866 Words
    • 3 Pages

    Steel is an alloy of iron and carbon. The proportion of carbon to iron varies the hardness of the alloy, the ductility and the tensile strength. Steel can be made stronger than pure iron however is also less ductile. If steel is soft, malleable and ductile it is used for sheet steel, nails and wires. If it is hard and moderately ductile, it is used for railway tracks and axles. If it is very hard with a very low malleability and is brittle, it is often used for axe heads, tools and high-strength wires.…

    • 866 Words
    • 3 Pages
    Good Essays
  • Good Essays

    Three test pieces EN 8, EN 16 and EN 24 were heated above their A3 temperature to create a homogeneous austenitic structure and then end quenched by means of water at 250C. Taking safety in to consideration it should be noted that the test piece should not be handled until the whole test piece has cooled down. After this the test piece was mounted in the Vickers hardness testing machine and then the hardness determined throughout the test piece. The measurements were taken from the quenched end at intervals of 1mm until 5mm and then the intervals of 2mm until 15mm and then intervals of 3mm until the end of the test specimen. The results were then tabulated (see fig 1.0)…

    • 1118 Words
    • 6 Pages
    Good Essays
  • Better Essays

    Mr Ms

    • 2101 Words
    • 7 Pages

    Materials engineering plays a crucial role in the design and production of parts for industrial applications. The mining industry is a dangerous example of industrial repetition and cyclic loading. When improper materials are selected, fatal outcomes can result, such as the accident at the Markham Colliery in 1973. The Markham Colliery was one of 14 producing mines in North Derbyshire, England, and during the time of the accident it output 30,000 tons of coal per week and employed nearly 2,300 men. Due to the complete failure the mechanical braking system of the winding engine, which transported men and materials up and down one of the shafts, 18 men lost their lives and several others were seriously injured. This accident occurred because the braking system was not properly designed. Operation of the brake over its lifetime produced higher than estimated bending forces on the system and induced fluctuating stresses on the braking rod that it could not sustain. Crack propagation developed in the rod due to bending stresses and eventually extended until fracture occurred, sending the cage of men to the bottom of the shaft at nearly 30 miles per hour. This paper examines the loading situation and presents a solution in regards to materials engineering, which would have prevented accident. Based on the loading conditions of the rod and its environment, SAE 4320 type steel that’s undergone a heat treatment will exhibit the most desirable properties. This carbon steel will show significantly decreased intergranular fatigue crack initiation and higher bending fatigue resistance.…

    • 2101 Words
    • 7 Pages
    Better Essays
  • Good Essays

    After testing the hardness of the annealed specimen with a 3,000 kg load, a 5.7 mm diameter indent was left on the surface, while the control had a 5.2 mm diameter indent. The hardness on the Brinell scale was HB 107 for the annealed specimen while the control had a hardness of HB 131. These results showed that the slow cooling of the steel softened the material.…

    • 579 Words
    • 3 Pages
    Good Essays
  • Good Essays

    9. It is clear that the microhardness number increases with increasing load. It is evident from the above plot that the microhardness number of the crystal increases with increase in load which is in agreement with the reverse indentation size effect (ISE) [15] and also decreases with increase in temperature. The decrease in the value of hardness number with respect to increase in temperature can be attributed to the fact that, when the temperature increases, the average inter atomic distance becomes greater than that at room temperature due to lattice vibration. This leads to more and more lattice phonon interactions which causes the breaking of bond as well reduce the hardness value [16]. The maximum value of hardness number observed for 2PPA, crystal is 39.9 kg/mm2 at 50 g (room temperature) respectively. The load above these values develops multiple cracks on the crystal surface due to the release of internal stresses generated locally by…

    • 719 Words
    • 3 Pages
    Good Essays
  • Powerful Essays

    Mechanical and Creep Testing

    • 3622 Words
    • 15 Pages

    The experiment consisted of two parts of investigation, Mechanical and Creep testing. Under mechanical testing, two medium carbon steel (04%) specimens that had been through different heat treatment were tested on tension and for hardness. One had been cold drawn and the other was normalised. The specimens were grinded using fine and coarse silicon carbide paper to give a smooth finishing before testing using a Vickers Hardness testing machine. The indenter was pressed into the specimens by an accurately controlled test force and the size of the indentation was observed by measuring the diagonals and averaging them out to get the Vickers hardness. The cold drawn specimen had a higher Vickers hardness of 285 and the…

    • 3622 Words
    • 15 Pages
    Powerful Essays
  • Powerful Essays

    Portal Frame Analysis

    • 2770 Words
    • 12 Pages

    The report primarily discusses results obtained from the conducted experiments and includes computed data from the Kingston computer program. The value of the plastic moment capacity of each experiment was obtained; Obtained value was used to find the yield strength of the structures and compare them to typical values for mild steel. The important data is summarized in a table; followed by a list of important formulae. All individual results are listed in the appendix at the end.…

    • 2770 Words
    • 12 Pages
    Powerful Essays
  • Better Essays

    1. To study the principle of impact testing by understanding the resistance of a material to crack propagation can be determined using impact test.…

    • 2517 Words
    • 11 Pages
    Better Essays
  • Good Essays

    Impact Value

    • 1144 Words
    • 5 Pages

    Toughness is the property of a material to resist impact. Due to traffic loads, the road stones are subjectedto the pounding action or impact and there is possibility of stones breaking into smaller pieces. The roadstones should therefore be tough enough to resist fracture under impact. A test designed to evaluate thetoughness of stone i.e., the resistance of the stones to fracture under repeated impacts may be called animpact test for road stones…

    • 1144 Words
    • 5 Pages
    Good Essays
  • Satisfactory Essays

    Materials

    • 932 Words
    • 4 Pages

    Alloy steel is often subdivided into two groups: high alloy steels and low alloy steels. The difference between the two is defined somewhat arbitrarily. However, most agree that any steel that is alloyed with more than eight percent of its weight being other elements beside iron and carbon, is high alloy steel. Low alloy steels are slightly more common. The physical properties of these steels are modified by the other elements, to give them greater hardness, durability, corrosion resistance, or toughness as compared to carbon steel. To achieve such properties, these alloys often require heat treatment..Example of an alloy…

    • 932 Words
    • 4 Pages
    Satisfactory Essays

Related Topics